Educational Guide

Honey Crystallization

Honey crystallization or granulation is a natural phenomenon by which honey turns from liquid (runny) state to a semi-solid state. Beekeepers refer to this as set honey.

Crystallization of honey is little understood by the consuming public. Many assume that honey appears crystallized to be an adulterated or unnatural product. That is not so. Actually, crystallization process is natural and spontaneous. Most pure raw or unheated honey has a natural tendency to crystallize over time. Crystallization does not affect the honey except for colour and texture. Crystallized honey is not spoiled and preserves the flavour and quality characteristics of the liquid honey. Some honey users like it in this state since it is easy to spread on bread or toast without dripping off and the taste is richer.

Bear in mind that crystallization of honey has no bearing on its quality, but it is an attribute of pure and natural honey.

Why honey crystallizes?

Honey is a highly concentrated sugar solution. It contains more than 70% sugars and less than 20% water. There is much sugar in honey relative to the water content. This means that the water in honey contains an extra amount of sugar than it could naturally hold. The overabundance of sugar makes honey unstable.

It is natural for honey to crystallize since it is an over-saturated sugar solution. The two principal sugars in honey are fructose (fruit sugar) and glucose (grape sugar). The content of fructose and glucose in honey varies from one type of honey to the other. Generally, the fructose ranges from 30- 44 % and glucose from 25- 40 %. The balance of these two major sugars is the main reason that leads to crystallization of honey, and the relative percentage of each determines whether it crystallizes rapidly or slowly. What crystallizes is the glucose, due to its lower solubility. Fructose is more soluble in water than glucose and will remain fluid. When glucose crystallizes, it separates from water and takes the form of tiny crystals. As the crystallization progresses and more glucose crystallizes, those crystals spread throughout the honey. The solution changes to a stable saturated form, and ultimately the honey becomes thick or crystallized.

Some honeys crystallize uniformly; some will be partially crystallized and form two layers, with the crystallized layer on the bottom of the jar and aliquid on top. Honeys also vary in the size of the crystals formed. Some form fine crystals and others large, gritty ones. The more rapid honey crystallizes, the finer the texture will be. Crystallized honey tends to set a lighter/paler colour than when liquid. This is due to the fact that glucose sugar tends to separate out in dehydrating crystals form, and that glucose crystals are naturally pure white. Darker honeys retain a brownish appearance.

How fast will honey crystallize?

Different types of honey will crystallize at different rates. Some honey crystallizes within a few weeks after extraction from the combs, whereas others remain liquid for months or years. The following factors influence the speed of crystallization:
(i) the nectar source collected by bees (the sugar composition of honey),
(ii) the methods in which honey is handled (processed) and
(iii) the temperature in preservation.

The time it will take the honey to crystallize depends mostly on the ratio of fructose to glucose, the glucose to water ratio. Honey high in glucose sugar, with a low fructose to glucose ratio will crystallize more rapidly, such as alfalfa, cotton, dandelion, mesquite, mustard and rape (brassica napus). Honey with a higher fructose to glucose ratio (containing less than 30% glucose) crystallizes quite slowly and can stay liquid for several years without special treatment, for example, robinia (black locust), sage, longan, tupelo and jujube/sidr (ziziphus spina-christi). The higher the glucose and the lower the water content of honey, the faster the crystallization. Oppositely, honey with less glucose relative to water is a less saturated glucose solution and is slow to crystallize. Honey with heightened water content often crystallizes unevenly (not as a homogeneous mass) and separates into crystallized and liquid parts.

The speed of honey to crystallize depends not only on its composition, but also on the presence of catalysts, like seed crystals, pollen grains and pieces of beeswax in the honey. These minute particles serve as nuclei for crystallization. Raw honey (unheated and unfiltered) contains bits of wax, pollen and propolis, and crystallizes faster. Honey that has been processed (e.g. heated and filtered) will remain in its liquid form longer than raw honey due to the elimination of nuclei, which encourage the growth of glucose crystals. Honey prepared for commercial market is usually heated and filtered. Heating and filtration of the honey dissolve any sugar crystals and remove foreign particles that might be present in it. Therefore, the crystallization is hindered.

The storage temperature has a big effect. Honey crystallization is most rapid around 10-15 ºC (50- 59 ºF). At temperature below 10 ºC (52 ºF) the crystallization is slowed down. Low temperature increases the viscosity of honey (honey is thicker when cool), and this retards the formation and diffusion of crystals. Honey resists crystallization best at higher temperatures more than 25 ºC (77 ºF). When the temperature is 40 ºC (104 ºF) the crystals dissolve. Temperature above 40 ºC (104 ºF) will damage the properties of honey.
The table below shows the relative speed of crystallization in descending order of various honeys.

Liquefying crystallized honey

Crystallized honey can be brought back to liquid consistency by gently heating it in a hot water bath (Bain Marie) or warming cabinet (box) until the honey re-liquefies. Heating should be applied indirectly, not by direct flame to a container. The temperature in the beehive is about 35 ºC (95 ºF) and can rise to 40ºC (104 ºF ) during summer periods when bees are ripening honey. In order to liquefy honey, it is best to heat it at 35-40 ºC (95-104 ºF). The temperature should not go beyond 40 ºC (104 ºF) to avoid overheating. Overheating honey for any period of time will reduce its quality by destroying its enzymes, loss the delicate flavour, aroma and darkening the honey colour. Heating must be done with care if the nutritional value of the honey is not to be spoiled. It is possible to re-liquefy crystallized honey without damaging its quality by the methods described below.

Hot water bath –
heat a saucepan filled with enough water to reach the level of honey in the jar to 35 - 40ºC (95-104 ºF), then remove it from the heat or turn off the heat. Take the lid off of the honey jar and immerse the jar in the water. Let it stand for about 20-30 minutes. The heat will slowly dissolve the glucose crystals and become liquid again. Stir occasionally to even the heat throughout the honey, as crystallized honey is a poor conductor of heat. Replace the hot water if needed. Remove the jar of honey from the water bath when honey becomes liquid again. This works well with honey in glass jars, but not so well with plastic containers. They can warp or melt. If honey is packaged in a plastic container set in warm water, not hot water. Honey in a plastic bucket can be re-liquefied by transferring or scooping it into glass jars, and the process above is used.

Honey warming cabinet –
another method to re-liquefy honey on a small scale is to heat it in a warming box with a 40 watt light bulb until it is liquid. This is a slow process and may take 12- 48 hours. The ideal box temperature is between 35-40 ºC, although some beekeepers use higher temperature to speed up liquefaction of the honey. A lower temperature at longer time is better for the honey. When the honey to be re-liquefied is in buckets, stir the bucket from time to time to speed up the process. A warming cabinet can be an insulated wooden box or a modified old refrigerator fitted with an electric light bulb at the base as the heat source and a thermostat to monitor the temperature. It is suitable for decrystallizing a stack of honey jars, or one or two buckets of 30 Ib. Building a warming box for your honey is easy. Basically, the process of construction is to heat the space with a light bulb. A light bulb provides a constant, steady heat. For information regarding making a honey heater, see the links below.

You can download the detailed information as pdf
Click Here to download pdf